Product ID:PENAIR HD-4 AEROSOL (MIL-PRF-87937C TYPE IV READY TO USE DIL
MSDS Date:06/28/1999
FSC:6850
NIIN:01-461-0070
MSDS Number: CKJTG

Emergency Phone: 201-567-3000

Info Phone: 201-569-5340

Preparer: NOT PROVIDED

Cage: 56883

Telephone: 201-567-3000

Cage: 56883

DIPROPYLENE GLYCOL METHYL ETHER

CAS: 34590-94-8

RTECS: JM1575000

OSHA PEL .100 PPM

ACGIH TLV: .100 PPM

LD50 LC50 Mixture:NOT PROVIDED
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:POTENTIAL HEALTH EFFECTS: EYE CONTACT:
IRRITATING TO THE EYES ON CONTACT ONLY. SKIN CONTACT: FREQUENT OR
PROLONGED CONTACT MAY IRRITATE OR DRY THE SKIN AND CAUSE
DERMATITIS. SKIN CONTACT MAY AGGRAVATE AN EXISTING DERMATITIS
CONDITION. INHALATION: INHALATION OF SPRAY MIST MAY CAUSE
IRRITATION TO THE RESPIRATORY TRACT, LIGHTHEADEDNESS AND HEADACHES.
INGESTION: INGESTION MAY CAUSE IRRITATION TO THE D IGESTIVE TRACT
AND DIARRHEA.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYE CONTACT: IRRITATING TO THE EYES ON CONTACT
ONLY. SKIN CONTACT: FREQUENT OR PROLONGED CONTACT MAY IRRITATE OR
DRY THE SKIN AND CAUSE DERMATITIS. INHALATION: INHALATION OF SPRAY
MIST MAY CAUSE IRRIT ATION TO THE RESPIRATORY TRACT,
LIGHTHEADEDNESS AND HEADACHES. INGESTION: INGESTION MAY CAUSE
IRRITATION TO THE DIGESTIVE TRACT AND DIARRHEA.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS CONDITION.

First Aid:EYE: FLUSH EYES WITH LARGE AMOUNT OF WATER. SEE PHYSICIAN
IMMEDIATELY. SKIN: FLUSH SKIN WITH LARGE AMOUNT OF WATER. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. IF SKIN IRRITATION
DEVELOPS OR PERSISTS, CONSULT PHYSICIAN. INHALATION: REMOVE
PERSON TO FRESH AIR. ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS
NEEDED. CALL A PHYSICIAN IMMEDIATELY. INGESTION: IF SWALLOWED GIVE
PLENTY OF WAT ER OR MILK. CALL A PHYSICIAN IMMEDIATELY.

Flash Point Method:TCC
Flash Point:NONE TO BOILING
Autoignition Temp:Autoignition Temp Text:N/D
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:NOT PROVIDED
Fire Fighting Procedures:COOL CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:AEROSOL CANS ARE UNDER PRESSURE. EXPOSURE
TO TEMPERATURES ABOVE 120 F CAN CAUSE BURSTING OR "ROCKETING" OF
CANS.THIS IS A WATER BASED PRODUCT AND PRESENT NO UNUSUAL HAZARDS
IN A FIRE. CONTAINERS CAN R UPTURE AND EXPLODE UNDER FIRE
CONDITIONS DUE TO PRESSURE AND VAPOR BUILD UP.

Spill Release Procedures:FOR SMALL SPILLS, USE ABSORBENT MATERIAL SUCH
AS TOWELS OR ABSORBENT POWDERS. PUT ALL MATERIAL INTO PROPER WASTE
DISPOSAL CONTAINER WITH LID TIGHTLY COVERED. FOR LARGE SPILLS, DIKE
SPILL, RECOVER FREE LIQUID, AND USE ABSORBENT MATERIAL TO DRY
AREA. RINSE AREA WITH WATER. PUT ALL MATERIAL INTO APPROPIATE
WASTE CONTAINER.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORAGE TEMPERATURE: AMBIENT. DO NOT
STORE ABOVE 120F MAY CAUSE CANS TO BURST. DO NOT PUNCTURE OR
INCINERQTE CANS. KEEP FROM FREEZING. DO NOT STORE NEAR STRONG
ACIDS.
Other Precautions:NOT PROVIDED

Respiratory Protection:NONE NORMALLY NEEDED.
Ventilation:FOR ENCLOSED AREAS OR WHERE LARGE AMOUNTS OF THE PRODUCT
ARE BEING USED, THE USE OF FANS OR OTHER MECHANICAL VENTILATION IS
RECOMMENDED.
Protective Gloves:SOLVENT RESISTANT GLOVES SHOULD BE USED.
Eye Protection:SAFETY GLASSES RECOMMENDED FOR ALL WORKPLACE
CONDITIONS.
Other Protective Equipment:NOT PROVIDED
Work Hygienic Practices:NOT PROVIDED
Supplemental Safety and Health
GENERAL USE: AIRCRAFT EXTERIOR CLEANER.

HCC:B3
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=100.C, 212.F
Melt/Freeze Pt:M.P/F.P Text:NOT PROVIDED
Decomp Temp:Decomp Text:NOT PROVIDED
Vapor Pres:MM HG@20C EQUAL TO WATER
Vapor Density:= TO WATER
Spec Gravity:1.00 (@75F)
VOC Pounds/Gallon:40
pH:8 TO 9
Viscosity:NOT PROVIDED
Evaporation Rate & Reference:(ACETONE=1)EQUAL TO WATER
Solubility in Water:SOLUBLE
Appearance and Odor:WATER WHITE TO SLIGHTLY HAZY LIQUID WITH A MILD
ODOR.
Percent Volatiles by Volume:4
Corrosion Rate:NOT PROVIDED

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, ALKALI, OXIDIZERS.
Stability Condition to Avoid:NOT PROVIDED
Hazardous Decomposition Products:SMOKE, FUMES AND OXIDES OF CARBON AND
NITROGEN.

Waste Disposal Methods:RCRA NON-HAZARDOUS WASTE.

Toxicological Information:NOT PROVIDED

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:SCQMD INFORMATION: IS THERE A PHOTOCHEMICALLY REACTIVE
MATERIAL PRESENT? NO. WHAT IS THE % BY VOLUME OF PHOTOCHEMICALLY
REACTIVE MATERIAL? 0. WHAT IS THE VOC CONTENT? 40G/L. WHAT IS THE
VAPOR PRESSURE OF VOC'S? <0.1 MM HG@ 20C.

Transport Information:DEPARTMENT OF TRANSPORTATION (DOT): PROPER
SHIPPING NAME: CONSUMER COMMODITY. HAZARD CLASS: ORM-D.
IDENTIFICATION NUMBER: NONE. PACKING GROUP: NONE. LABEL:NOT
REQUIRED.

SARA Title III Information:311/312 HAZARD CATEGORIES: ACUTE HEALTH. 313
EREPORTABLE INGREDIENTS: NONE.
Federal Regulatory Information:TSCA: THE INGREDIENTS IN THIS PRODUCT
ARE LISTED ON THE TSCA INVENTORY. CERCLA: THIS PRODUCT DOES NOT
REQUIRE REPORTING UNDER CERCLA. CONTACT LOCAL AUTHORITIES TO
DETERMINE IF THERE MAY BE OTHER LOCAL REPORTING REQUIREMENTS. RCRA
HAZARD CLASS: NONHAZARDOUS WASTE.
State Regulatory Information:NEW JERSEY RIGHT-TO-KNOW INFORMATION: THIS
PRODUCT CONTAINS WATER, NONYLPHENOLETHOXYLATE, DIPROPYLENE GLYCOL
PROPYL ETHER, DIPROPYLENE GLYCOL METHYLETHER, COCONUT
DIETHANOLAMINE, AND NITROUS OXIDE. CA LIFORNIA: THIS PRODUCT DOES
NOT CONTAIN ANY CHEMICALS RECOGNIZED BY THE STATE OF CALIFORNIA TO
CAUSE CANCER AND/OR BIRTH DEFECTS OR REPRODUCTIVE HARM.